Material Safety Data Sheet
Product No. 814-310, 814-312, 814-314, 814-316, 814-318, 814-320, 814-322, 814-324, 814-326, 814-328 Polycrystalline Diamond Suspension 0.1, 0.25, 0.5, 1.0, 3.0, 6.0, 9.0, 15, 30, 45 µm
Issue Date (04-19-03)
Review Date (09-14-11)
Section 1: Product and Company Identification
Product Name: Polycrystalline Diamond Suspension 0.1, 0.25, 0.5, 1.0, 3.0, 6.0, 9.0, 15, 30, 45 µm
Synonym: None
Company Name
Ted Pella, Inc., P.O. Box 492477, Redding, CA 96049-2477
Domestic Phone (800) 237-3526 (Mon-Thu.
International Phone (01) (530) 243-2200 (Mon-Thu.
Chemtrec Emergency Number 1-800-424-9300 24 hrs a day.
Section 2: Composition / Information on Ingredients
|
Principle Hazardous Component(s)
|
% |
OSHA mg/m3 |
ACGIH |
NTP |
IARC |
OSHA |
|
K-Gel(None) |
ND |
ND |
ND |
ND |
ND |
ND |
|
Ethylene Glycol (107-21-1) |
25 |
50 PPM |
50PPM |
No |
No |
No |
|
*Propylene Glycol (57-55-6) |
ND |
NE |
NE |
No |
No |
No |
* TW: 10 mg/M3 from AIHA
Section 3: Hazard Identification
Emergency overview
Appearance: Liquid
Immediate effects: ND
Potential health effects
Primary Routes of entry: Skin, inhalation
Signs and Symptoms of Overexposure: ND
Eyes: NE
Skin: NE
Ingestion: NE
Inhalation: NE
Chronic Exposure: NE
Chemical Listed As Carcinogen Or Potential Carcinogen: None
See Toxicological Information (Section11)
Potential environmental effects
See Ecological Information (Section 12)
Section 4: First Aid Measures
If accidental overexposure is suspected
Eye(s) Contact: Wash out eyes for minimum of 15 minutes.
Skin Contact: Wash affected area with soap and water.
Inhalation: Remove to fresh air
Ingestion: Give plenty of fluids; Seek medical attention immediately.
Note to physician
Treatment: ND
Medical Conditions generally Aggravated by Exposure: ND
Section 5: Fire Fighting Measures
Flash Point: 241 ºF
Flammable Limits: NE
Auto-ignition point: NE
Fire Extinguishing Media: Alcohol foam, carbon dioxide, dry chemical, water
spray.
Special Fire Fighting Procedures: ND
Unusual Fire and Explosion Hazards: None known
Hazardous combustion products: Carbon dioxide and carbon monoxide.
DOT Class: Not regulated.
Section 6: Accidental Release Measures
Steps to be Taken in Case Material is Released or Spilled: Use inert material;
prevent material from spreading; dispose of immediately; wear protective
equipment.
Waste Disposal Methods: Dispose of waste according to Federal, State and Local
Regulations.
Section 7: Handling and Storage
Precautions to be Taken in Handling and Storage: Store at room temperature,
plus or minus 10 degrees, with adequate ventilation. Keep containers closed
until ready to used
Storage temperature: Room temperature.
Storage Pressure: NA
Section 8: Exposure Controls / Personal Protection
Engineering Controls
Ventilation required: Adequate ventilation.
Personal Protection Equipment
Respiratory protection: Adequate ventilation.
Protective gloves: Rubber gloves.
Skin protection: Protective clothing.
Eye protection: Goggles or safety glasses.
Additional clothing and/or equipment: ND
Exposure Guidelines
See Composition/Information on Ingredients (Section2)
Section 9 Physical and Chemical Properties
Appearance and Physical State: Liquid, color varies with micron size.
Odor (threshold): Mild
Specific Gravity (H2O=1): ND
Vapor Pressure (mm Hg): ND
Vapor Density (air=1): ND
Percent Volatile by volume: ND
Evaporation Rate (butyl acetate=1): ND
Boiling Point: ND
Freezing point / melting point: ND
pH: ND
Solubility in Water: Soluble
Molecular Weight: NA
Section 10: Stability and Reactivity
Stability: Stable
Conditions to Avoid: ND
Materials to Avoid (Incompatibility): Strong oxidizing agents.
Hazardous Decomposition Products: Carbon monoxide and carbon dioxide when
heated to decomposition.
Hazardous Polymerization: Will not occur
Section 11: Toxicological Information
Results of component toxicity test performed:
Ethylene Glycol (107-21-1), Rat (Oral) LD50: 4700 mg/kg; Rabbit (Skin) LD50: 9530 mg/kg. Irritation - skin rabbit: 555mg(open), mild; eye rabbit: 500mg/24H, mild.
Propylene Glycol (57-55-6), Rat (Oral) LD50: 20g/kg. Rabbit (Skin) LD50: 20.8g/kg. Irritation: Eye rabbit/Draize, 500 mg/24H mild.
Human experience: ND
This product does not contain any compounds listed by NTP or IARC or regulated by OSHA as a carcinogen.
Section 12: Ecological Information
Ecological Information: ND
Chemical Fate Information: ND
Section 13 Disposal Considerations
RCRA 40 CFR 261 Classification: None listed
Federal, State and local laws governing disposal of materials can differ. Ensure proper disposal compliance with proper authorities before disposal.
Section 14: Transportation Information
US DOT Information: Proper shipping name: Not regulated
IATA: Proper shipping name: Not regulated
IMO: Proper shipping name: Not regulated
Marine Pollutant: No
Canadian TDG: Not regulated
Section 15: Regulatory Information
MSDS complies with OSHA’s Hazard Communication Rule 29, CFR 1910.1200.
SARA: Section 302: None listed
SARA Title III: Section313: Ethylene Glycol (107-21-1) listed.
RCRA: None listed
TSCA: Chemical Inventory Status listed components: Ethylene Glycol (107-21-1) 12(b) No, 8 (d) No, Propylene Glycol (57-55-6) 12(b) No, 8 (d) No.
CERCLA: Ethylene Glycol (107-21-1), RQ = 5000 LBS (2277 Kg)
State Regulations
California Proposition 65: None listed
International Regulations
Canada WHMIS: Ethylene Glycol (107-21-1) DSL: Yes, NDSL: No. Propylene Glycol (57-55-6) DSL: Yes, NDSL: No
Europe EINECS Numbers: ND
Section 16: Other Information
Label Information: May cause irritation to eyes and skin.
European Risk and Safety Phrases: ND
European symbols needed: ND
Canadian WHMIS Symbols: ND
Estimated NFPA Hazard Rating: Health: 1; Fire: 1 Reactivity: 0
(0=least, 1=Slight, 2=Moderate, 3=High, 4=Extreme)
Abbreviations used in this document
NE= Not established
NA= Not applicable
NIF= No Information Found
ND= No Data
Disclaimer
Ted Pella, Inc. makes no warranty of any kind regarding the information
furnished herein. Users should independently determine the suitability and
completeness of information from all sources. While this data is presented in
good faith and believed to be accurate, it should be considered only as a
supplement to other information gathered by the user. It is the User's
responsibility to assure the proper use and disposal of these materials as well
as the safety and health of all personnel who may work with or otherwise come
in contact with these materials.
MSDS Form 0013F1 V2